攪拌車對于裝置配件主要都有什么呢？日常要怎么做處理，會容易出現什么狀況，其實保持機器干凈，及時調整、緊固松動的零部件，這只是其中一點要日常經常做的，下面跟著小編看還有什么其他事項吧。
What are the main parts of the mixer for the device? How to deal with it in daily life and what will happen easily. In fact, keep the machine clean, adjust and tighten loose parts in time. This is just one of the things that we should do frequently in daily life. Let's follow the editor to see what else we have to do.
檢查除塵器各蝶閥與攪拌車的聯動情況;主動除塵風機、除塵器反吹裝置、震動器工作狀態;檢查吸塵管路有無破裂、吸塵管內粉塵堆積情況及清理;除塵器積料部粉塵的堆積情況和清理。
Check the linkage between each butterfly valve of the dust collector and the mixer; The working state of active dust removal fan, dust collector back blowing device and vibrator; Check whether the dust collection pipeline is broken, and the dust accumulation in the dust collection pipe and cleaning; Accumulation and cleaning of dust in the material accumulation part of the dust collector.
料斗內粘著物清缸、供氣管路油杯檢查加注、油水分離器積水排放五、各配電箱的防護門關閉完好，粉塵;盤點清理工具并上鎖;搞好工具室、電器室環境衛生。軸端密封、軸端軸承按規定定時加注潤滑脂，對同步齒輪、動力鏈條、動力主減速箱、動力電機軸承每班檢查，按規定定時加注或更換潤滑油。
Clean the adhesion in the hopper, check and fill the oil cup of the air supply pipeline, and drain the water in the oil-water separator. V. the protective door of each distribution box is closed and intact, and the dust is removed; Check and clean tools and lock them; Do a good job in environmental sanitation of tool room and electrical room. The shaft end seal and shaft end bearing shall be filled with lubricating grease regularly according to the regulations. The synchronous gear, power chain, power main reducer and power motor bearing shall be checked every shift, and the lubricating oil shall be filled or replaced regularly according to the regulations.
使用完全自動攪拌車，也要定期清理、保養，正確的使用、清理可延長攪拌機的使用壽命，要定期對攪拌車進行保養規程所規定項目的維護、保養作業，如清洗、潤滑、加油等。
When using a fully automatic mixer, it is also necessary to clean and maintain it regularly. Correct use and cleaning can prolong the service life of the mixer. It is necessary to regularly carry out the maintenance and servicing of the items specified in the maintenance procedures, such as cleaning, lubrication, refueling, etc.
在冬季使用時，要注意工作完畢后應該用水清洗攪拌車滾筒并將水泵、水箱、水管內積水放凈，以免水泵、水箱、水管等凍壞。要記得不能用大錘擊打的辦法根除積存在攪拌車筒內的混凝土，只能用鑿子。
When using in winter, it should be noted that after the work is completed, the drum of the mixer truck should be cleaned with water and the accumulated water in the water pump, water tank and water pipe should be drained to avoid freezing damage of the water pump, water tank and water pipe. Remember that you can't use a sledgehammer to eradicate the concrete accumulated in the mixer drum, but only use a chisel to remove it.
攪拌車使用前要先檢查各控制器是否良好，停工后用水和石子倒入攪拌筒內10~15分鐘進行清洗，再將水和石子清出。操作人員如須進入攪拌筒內清洗時，除切斷電源和卸下熔斷器外，還需要鎖好開關箱。
Before using the mixer truck, check whether each controller is in good condition. After shutdown, pour water and stones into the mixing drum for 10-15 minutes for cleaning, and then remove the water and stones. If the operator needs to enter the mixing drum for cleaning, he should not only cut off the power supply and remove the fuse, but also lock the switch box.
此外
自動攪拌車滿載混凝土正轉時，如要反轉，必須操縱手柄使正轉停穩后，再操縱手柄反轉。嚴禁正轉過程中操縱手柄使其反轉。在水箱沒有卸壓之前不可打開進水閥。卸料溜槽、加長溜槽是否需要一起使用，由具體工作位置的要求來決定。水箱沒有卸壓之前不可開車行駛。冬季停放時，水箱和供水系統里，不得有剩余水。非操作人員，禁止操作。
In addition, when the automatic mixer truck rotates forward with full load of concrete, if you want to reverse, you must control the handle to make the forward rotation stop stably, and then control the handle to reverse. It is strictly forbidden to reverse the joystick during forward rotation. Do not open the water inlet valve before the water tank is depressurized. Whether the discharge chute and the extended chute need to be used together depends on the requirements of the specific working position. Do not drive until the water tank is depressurized. When parking in winter, there shall be no residual water in the water tank and water supply system. Non operators are forbidden to operate.
The above is the relevant content of the question answer. I hope it can help you. If you still have any questions about this problem, you are welcome to follow our website http://jackpetty.net And consult our staff, will serve you wholeheartedly.
點擊撥打服務熱線：4008791999
