RM新时代官方-首页

攪拌一體車在混凝土工程項目在起到舉足輕重的地位，所以每日工作后的養護工作必不可少。下面就來看看有哪些維護工作要做吧。

The all-in-one mixer plays an important role in the concrete engineering project, so the maintenance after daily work is essential. Let's take a look at the maintenance work to be done.

每天目測發動機、減速器、液壓泵、液壓馬達、油箱是否漏油。

Visually inspect the engine, reducer, hydraulic pump, hydraulic motor and oil tank for oil leakage every day.

檢查水箱、水管是否漏水，并檢查水箱的儲水量。

Check whether the water tank and water pipe leak, and check the water storage capacity of the water tank.

檢查工作燈、示寬燈、側標志燈的燈光。

Check the lights of work lights, side marker lights and side marker lights.

檢查輪胎氣壓及輪胎螺絲的松緊情況。

Check the tire pressure and the tightness of tire screws.

檢查工作記錄，保養維修記錄，交接班記錄是否完善。

Check whether the work records, maintenance and repair records and shift handover records are complete.

在行駛過程中，隨時注意異響、異味和各工作儀表。

During driving, pay attention to abnormal noise, peculiar smell and various working instruments at any time.

水泥攪拌機工作完成后工作人員務必整理拌和機內雜物及殘料。

After the cement mixer is completed, the staff must sort out the sundries and residues in the mixer.

每日工作后水泥攪拌機各光滑點加注光滑油。

Add smooth oil to each smooth point of the cement mixer after daily operation.

在冬天水泥攪拌機應放凈增加劑及供水體系管路內液體，以防凍裂。

In winter, the cement mixer shall discharge the additive and the liquid in the water supply system pipeline to prevent cracking.

水泥攪拌機每天工作后放凈空壓機儲氣筒內的氣體及積水。

After the cement mixer works every day, discharge the gas and water in the air storage tank of the air compressor.

攪拌機停機后斷開總電源和微機電源。

Disconnect the main power supply and microcomputer power supply after the mixer stops.

每次操作業完畢后，攪拌一體車清洗干凈。通常狀況下，攪拌拖泵在作業了一段時間后維護保養是須的，除了平常維護的項目內容之外，還需求進一步的維護，查看和調整制動間隙。

After each operation, the mixer truck shall be cleaned. Under normal conditions, it is necessary to maintain the mixing drag pump after a period of operation. In addition to the normal maintenance items, further maintenance is required to check and adjust the brake clearance.

例如離合器內，外制動帶磨損嚴重須更換，調整攪拌葉片和刮板與襯板之間的空隙，上料斗和卸料門的密封及靈敏狀況，離合器的磨損程度以及配水系統算法正常。采用鏈條傳動的攪拌拖泵還需查看鏈條節距的伸長狀況。更多相關內容就來我們網站http://jackpetty.net咨詢了解吧。

For example, the inner and outer brake belts of the clutch are seriously worn and must be replaced. Adjust the clearance between the mixing blade and the scraper and the lining plate, the sealing and sensitivity of the upper hopper and the discharge door, the wear degree of the clutch and the algorithm of the water distribution system are normal. For the mixing drag pump with chain drive, it is also necessary to check the elongation of the chain pitch. For more information, please visit our website http://jackpetty.net Consult and understand.